TITLE 41: FIRE PROTECTION CHAPTER III: BOARD OF BOILER AND PRESSURE VESSEL RULES PART 2120 BOILER AND PRESSURE VESSEL SAFETY The General Assembly's Illinois Administrative Code database includes only those rulemakings that have been permanently adopted. This menu will point out the Sections on which an emergency rule (valid for a maximum of 150 days, usually until replaced by a permanent rulemaking) exists. The emergency rulemaking is linked through the notation that follows the Section heading in the menu. View Entire Part SUBPART A: DEFINITIONS AND ADMINISTRATION Section 2120.10 Definitions Section 2120.20 Incorporation of National Standards Section 2120.30 Fees Section 2120.40 Administration Section 2120.50 Inspectors, Examinations, Certificate of Competency and Commission. SUBPART B: CONSTRUCTION, INSTALLATION, INSPECTION, MAINTENANCE, AND USE Section 2120.100 New Installations of Boilers, Miniature Boilers, Heating Boilers and Hot Water Supply Boilers Section 2120.200 New Installations of Pressure Vessels Section 2120.300 Existing Installations of Power Boilers Section 2120.400 Operation of Boilers and Pressure Vessels Section 2120.500 Existing Installation of Pressure Vessels SUBPART C: REPAIR AND ALTERATION Section 2120.1000 Repairs and Alterations to Boilers and Pressure Vessels by Welding Section 2120.1010 Authorization to Repair Boilers and Pressure Vessels Section 2120.1020 Issuance and Renewal of the Certificate Section 2120.1030 Changes to Certificates of Authorization Section 2120.1040 Quality Control Requirements Section 2120.1041 Repair and Alteration Requirements SUBPART D: STATE SPECIALS Section 2120.1100 Procedure for the Issuance of a State Special Permit SUBPART E: REPAIR OF SAFETY AND SAFETY RELIEF VALVES Section 2120.1200 Authorization for Repair of Safety & Safety Relief Valves Section 2120.1210 Authorization to Repair ASME and National Board Stamped Safety and Safety Relief Valves Section 2120.1220 Issuance and Renewal of the Certificate Section 2120.1240 Changes to Certificates of Authorization Section 2120.1250 Repairs to Safety and Safety Relief Valves Section 2120.1260 Quality Control System Section 2120.1270 Nameplates Section 2120.1275 Field Repair Section 2120.1280 Performance Testing of Repaired Valves Section 2120.1285 Training of Valve Repair Personnel Section 2120.1290 ASME "V", "UV" or National Board "VR" Certificate Holders SUBPART F: OWNER-USER QUALITY CONTROL REQUIREMENTS Section 2120.1300 Introduction Section 2120.1301 Authority and Responsibility Section 2120.1305 Organization Section 2120.1310 Inservice Inspection Program Section 2120.1320 Drawings, Design Calculations and Specification Control Section 2120.1325 Material Control Section 2120.1330 Examination and Inspection Program Section 2120.1335 Correction of Nonconformities Section 2120.1340 Welding Section 2120.1345 Nondestructive Examination Section 2120.1350 Calibration of Measurement and Test Equipment Section 2120.1355 Records Section 2120.1360 Inspectors SUBPART G: HISTORICAL BOILERS Section 2120.1400 Scope Section 2120.1410 Historical Boiler Definition Section 2120.1420 Historical Boiler Inspections Section 2120.1430 Fees Section 2120.1440 Repairs and Alterations Section 2120.APPENDIX A Operational and Maintenance Log Section 2120.EXHIBIT A Hot Water Heating Boilers Section 2120.EXHIBIT B Steam Heating Boilers

AUTHORITY: Implementing the Boiler and Pressure Vessel Safety Act [430 ILCS 75] and authorized by Sections 2 and 2.1 of the Boiler and Pressure Vessel Safety Act [430 ILCS 75/2 and 2.1].

SOURCE: Boiler and Pressure Vessel Safety Act Rules and Regulations adopted at 4 Ill. Reg. 7, p. 126, effective January 31, 1980; codified at 5 Ill. Reg. 10677; amended at 7 Ill. Reg. 6925, effective July 1, 1983; amended at 10 Ill. Reg. 9510, effective July 1, 1985; amended at 11 Ill. Reg. 16587, effective January 1, 1988; amended at 16 Ill. Reg. 6808, effective July 1, 1992; amended at 17 Ill. Reg. 14917, effective September 1, 1993; amended at 19 Ill. Reg. 11904, effective August 15, 1995; amended at 20 Ill. Reg. 9540, effective July 3, 1996; amended at 21 Ill. Reg. 997, effective January 1, 1997; amended at 23 Ill. Reg. 162, effective January 1, 1999; amended at 24 Ill. Reg. 18555, effective December 7, 2000; amended at 25 Ill. Reg. 11914, effective January 1, 2002; amended at 27 Ill. Reg. 518, effective January 01, 2003; emergency amendment at 27 Ill. Reg. 14855, effective September 2, 2003, for a maximum of 150 days; amended at 28 Ill. Reg. 1737, effective January 13, 2004; amended at 28 Ill. Reg. 13509, effective September 24, 2004; amended at 32 Ill. Reg. 17198, effective October 16, 2008; amended at 35 Ill. Reg. 9028, effective July 1, 2011; amended at 37 Ill. Reg. 13424, effective August 1, 2013; amended at 38 Ill. Reg. 18925, effective September 4, 2014; recodified from Chapter I, 41 Ill. Adm. Code 120, to Chapter III, 41 Ill. Adm. Code 2120, at 39 Ill. Reg. 10645; amended at 41 Ill. Reg. 846, effective January 17, 2017; amended at 42 Ill. Reg. 13457, effective July 1, 2018; amended at 44 Ill. Reg. 13968, effective August 13, 2020; amended at 46 Ill. Reg. 6907, effective May 1, 2022; amended at 48 Ill. Reg. 3420, effective February 21, 2024; expedited correction at 48 Ill. Reg. 9121, effective February 21, 2024.